Product ID:SHEETING BOND-WHITE, 046-505-996
MSDS Date:01/28/1991
FSC:8040
NIIN:00N049561
MSDS Number: BVHXR

TREMCO

3735 GREEN RD
BEACHWOOD, OH 44122
US

Emergency Phone: 216-765-6727;800-424-9300(CHEMTREC)

Info Phone: 216-292-5000

Cage: TRMC0

TREMCO INC

CLEVELAND, OH 44128 US

Telephone: 216-752-4400

Cage: 94529

CALCIUM CARBONATE (LIMESTONE)

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 55%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

BUTENE, POLYMERS; (POLYBUTENE) (MFR CAS # 9003-29-6)

CAS: 9003-29-6

RTECS: EM9032000

Fraction By Weight: 15%

OSHA PEL N/K

ACGIH TLV: N/K

PROPENE, 2-METHYL-, POLYMERS; (POLYISOBUTYLENE)

CAS: 9003-27-4

RTECS: UD1010000

Fraction By Weight: 10%

OSHA PEL N/K

ACGIH TLV: N/K

XYLENES; (DIMETHYLBENZENES) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 8%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED (MILD)

CAS: 64741-88-4

RTECS: PY8040500

Fraction By Weight: 5%

OSHA PEL N/K

ACGIH TLV: N/K

SILICA (AMORPHOUS)

CAS: 7631-86-9

Fraction By Weight: 5%

OSHA PEL 6 MG/M3

ACGIH TLV: 6 MG/M3

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 5-10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

BENZENE, ETHYL-; (ETHYL BENZENE) (SARA III)

CAS: 100-41-4

RTECS: DA0700000

Fraction By Weight: 3%

OSHA PEL 100 PPM;125 PPM STEL

ACGIH TLV: 100 PPM;125 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.6%

OSHA PEL N/K

ACGIH TLV: 0.1 MG/M3 RDUST

LIVER EFFECTS IN LABORATORY ANIMALS.

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

THORO AFTER HNDLG. PRECS FOR REPAIR &

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

DURING MAINTANENCE/REPAIR OF CONTAMD MIXER,

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

FOR INDUSTRIAL USE ONLY. KEEP OUT OF REACH OF

RTECS: 9999999ZZ

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE: CAN CAUSE IRRIT. SKIN: CAN
CAUSE IRRIT, DERM. INHAL: CAN CAUSE HDCH, DIZZ, IRRIT TO RESP SYS.
INGEST: CAN CAUSE GI IRRIT. CHRONIC: PRLNGD & RPTD OVEREXP TO FREE
CRYSTALLINE SILICA DUST ABOV E TLV LEVEL MAY CAUSE SCARRING OF
LUNGSW/COUGH & SHORT OF BRTH. DELAYED LUNG INJ, SILICOSIS MAY RSLT
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC
MONOGRAPHS, SUPPLEMENT. VOL 7, PG 341, 1987: GRP 2A. NTP 6TH ANNUAL
REPORT ON (SUPDAT)
Effects of Overexposure:HLTH HAZ: FROM BRTHG FREE SILICA. HOWEVER,
SILICA IN PROD IS ENCAPSULATED & RELS IS NOT EXPECTED UNLESS IT IS
NEC TO ABRADE, GRIND/SAND SURFS COATED W/PROD. RPTS HAVE ASSOC RPTD
& PRLNGD OCCUP OVEREXP TO SOLVS W/PERM BRAIN & NERV SYS DMG.
INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS MAY BE
HARMFUL/FATAL. (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN: WASH AREA OF CONC THORO W/HAND CLEANER FOLLOWED BY SOAP
& WATER. IF IRRIT, RASH/OTHER DISORDERS DEVELOP, GET MED ATTN
IMMED. EYES: FLUSH IMMED W/RUNNING WATER FOR AT LST 15 MINS,
LIFTING UPPER & LOWER LIDS OCCAS. GET MED ATTN IMMED. INGEST: GET
MED ATTN IMMED. INHAL: LEAVE AREA TO BREATHE FRESH AIR. AVOID
FURTHER OVEREXPOSURE. IF SYMPTOMS PERSIST, GET MEDICAL ATTENTION
IMMEDIATELY.

Extinguishing Media:IF WATER FOG IS INEFFECTIVE, USE CARBON DIOXIDE,
DRY CHEMICAL OR FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NEVER USE WELDING OR CUTTING TORCH ON OR
NEAR CONTAINER (EVEN EMPTY). PRODUCT, RESIDUE OR VAPOR MAY IGNITE.
SEE HANDLING AND STORAGE FOR ADDITIONAL PRECAUTIONS.

Spill Release Procedures:REMOVE SOURCES OF IGNITION IMMEDIATELY.
VENTILATE TO REDUCE AIRBORNE CONTAMINANT CONCENTRATION BELOW
EXPOSURE LIMIT. ABSORB SPILL IN SAND, EARTH OR OTHER SUITABLE
MATERIAL. TRANSFER TO DOT APPROVED CO NTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN CLOSED CONTAINER BELOW 80F.
KEEP PRODUCT AND VAPOR AWAY FROM HEAT, SPARKS AND FLAME. DO NOT
STORE IN DIRECT SUNLIGHT.
Other Precautions:PREVENT INHAL OF VAP, INGEST & CONT W/SKIN & EYES.
KEEP CNTNR CLSD WHEN NOT IN USE. VAP MAY MIGRATE TO SOURCES OF
IGNIT. DO NOT SMOKE, WELD, GENERATE SPARKS/USE FLAME NEAR CNTNR.
CHANGE SOILED WORKCLO THES FREQUENTLY. CLEAN HANDS (ING 11)

Respiratory Protection:WEAR APPROPRIATE, PROPERLY FITTED NIOSH/MSHA
APPROVED RESPIRATOR WHEN AIRBORNE CONTAMINANT LEVEL(S) EXCEED
EXPOSURE LIMITS INDICATED IN INGREDIENTS SECTION. FOLLOW RESPIRATOR
MANUFACTURER'S DIRECTIONS FOR RESPIRATOR USE.
Ventilation:USE LOC EXHST WHEN GEN VENT IS NOT SUFF TO KEEP AIRBORNE
CONTAM CONC BELOW EXPOS LIMIT IN INGREDIENTS SECTION OF MSDS.
Protective Gloves:IMPERVIOUS RUBBER GLOVES.
Eye Protection:USE SUITABLE SAFETY EYEWEAR.
Other Protective Equipment:TYPICAL FULL COVER CLOTHING.
Work Hygienic Practices:PVNT CONT W/SKIN.GLOVES MUST BE CHECKED BEFORE
EACH USE FOR SIGNS OF DEGRADATION & PENETRATION & FOR PROPER
FUNCTIONING.
Supplemental Safety and Health
EXPLAN OF CARCIN: CARCINS, 1991: ANTIC TO BE CARCIN. EFTS OF OVEREXP:
OVEREXP TO XYLENE CAN ADVERSELY AFFECT CNS, HEART, LIVER, KIDNEYS,
LUNGS, SPLEEN & ADRENALS. EMBRYO/FETOTOXICITY OCCURED IN PREGNA NT
RATS EXPOS BY INHAL & MICE EXPOS ORALLY (W/MATERNAL TOX) TO XYLENE.
OVEREXP TO ETHYL BENZENE BY INHAL CAUSED (ING 10)

Vapor Density:>1 (AIR=1)
Spec Gravity:1.56
Evaporation Rate & Reference:>1 (ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:WHITE PASTE, SOLVENT ODOR.
Percent Volatiles by Volume:11(WT)

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:SUBJECT TO HAZARDOUS WASTE TREATMENT, STORAGE
AND DISPOSAL REQUIREMENTS UNDER RCRA. INCINERATE AT EPA APPROVED
FACILITY OR DISPOSE OF IN COMPLIANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. EPA HAZAR DOUS WASTE NUMBER: D018. EPA RQ: 10#.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.